$100 Ideas - September 2018

20:04PM Aug 21, 2018

$100 Ideas - September 2018( Illustrations: Bob Cunningham )

$200 Double Your Money Winner:
Power Sweeper Makes Cleaning Easier

For $200 I made a power sweeper to clean the floor of our tiestall barn. Using an old pull-start snow blower, I cut off the auger and chute assembly but left the drive system. I attached a gearbox from an old auger so the snow blower’s clutch could still engage. I ran a shaft from the center of the gearbox and attached the brush using tubing, pipes and bearings. A belt drives the brush. The shield is made from 15-gal. buckets cut in half and bolted together. Jacob, a high school junior, farms with his dad at Hillview-S-Holsteins.

Jacob Schroeder
Fergus Falls, Minn.


Tool Simplifies PTO Hook Up

I found it difficult to line up the splines, pull back the retainer ring and push the heavy PTO shaft forward while hooking the baler PTO to the tractor. I simplified this task by making a small U-shaped fork out of 1/16"x5/16" flat iron. The fork is bent to fit securely over the PTO shaft so the retainer ring remains in the unlocked position.

Tom Cook
Decatur, Texas


Engine Block Heater Indicator Light

During the winter months, plugging in my tractor’s engine block heater is a must. Forgetting to unplug the block heater on the tractor often resulted in broken extension cords. So I mounted a 120-volt light to the dashboard of my tractor and wired it to the block heater’s power. Now when I start the engine, I can see if my tractor is still plugged in.

Simon Hofer
Sioux Falls, S.D.

 

Tags:
This block is broken or missing. You may be missing content or you might need to enable the original module.
This block is broken or missing. You may be missing content or you might need to enable the original module.